因為這是一種用于小型釀酒設備的快速冬季發酵方法?在釀酒的過程中，釀酒的方法有很多，固體酒就是其中之一，通過固體酒的釀造方法使葡萄酒的口感很好，葡萄酒的品質也很好。由于這種方法的釀造周期相對較短，但受溫度影響較大，所以在夏季升溫過快，在冬季溫度較低時容易失效。面對寒冬，采用固體釀造方法時應注意些什么。我們要考慮到冬季氣溫較低，水分蒸騰較少，且少用新糧多在年中，含水分較多，有必要試驗一下豬水，因地制宜，不能盲目加硬線。一般情況下，如果水太大，酒糟會發粘，空隙小，含氧量低，好氧酵母就無法生長繁殖。Becausethisisafastwinterfermentationmethodforsmall-scalebrewingequipment?Therearemanywaystomakewineintheprocessofbrewing.Solidwineisoneofthem.Thesolidwinebrewingmethodmakesthewinetastegoodandthequalityofthewineisgood.Becausethebrewingcycleofthismethodisrelativelyshort,butitisgreatlyaffectedbythetemperature,sothetemperaturerisestoofastinsummer,anditiseasytofailinwinterwhenthetemperatureislow.Inthefaceofcoldwinter,whatshouldwepayattentiontowhenusingsolidbrewingmethod.Weshouldconsiderthatthewintertemperatureislower,thewatertranspirationisless,andthenewgrainislessusedinthemiddleoftheyear,andthewatercontentismore.Itisnecessarytotestthepigwater,adjustmeasurestolocalconditions,anddonotblindlyaddhardlines.Ingeneral,ifthewateristoolarge,thedistiller'sgrainswillbesticky,thespaceissmall,theoxygencontentislow,andtheaerobicyeastwillnotbeabletogrowandreproduce.
所以池子里的水應該在54%到56%之間。溫度是很重要的，要適當提高固體發酵是否仍然是液體發酵。夏季氣溫略低，冬季氣溫略高，夏季氣溫略低，冬季可迅速降溫。它可以控制在大約36度。為保證下一曲曲酒的正常發酵，培養箱應蓋上棉被等可保溫或直接在連續溫室糖化的物品。二是進展到池水溫度，正常條件下要到酒窖溫度，高分辨率發酵率和火焰溫度，控制好水溫，掌握好礦坑溫度，以適應微生物的生長和代謝。因此，在冬季，當溫度較低時，發酵谷物的干燥和koji種子的混合稍微延遲，發酵谷物的溫度迅速下降。當溫度低于13℃時，霉菌的糖化和酵母的發酵受到抑制。發酵后，谷粒表面覆蓋著白色的酸甜菌絲，底部幾滴糖液的溫度上升到醉酒的高度，開始下降。糖化結束時，溫度進入醉池。，加熱和保溫。為了保證糖化和液化過程的正常進行，有必要保證整個發酵過程所需的溫度。Sothewaterinthepoolshouldbebetween54%and56%.Temperatureisveryimportanttoproperlyimprovewhethersolidfermentationisstillliquidfermentation.Thetemperatureisslightlylowerinsummer,slightlyhigherinwinter,slightlylowerinsummer,andrapidlycooledinwinter.Itcanbecontrolledatabout36degrees.InordertoensurethenormalfermentationofthenextQuliquor,theincubatorshouldbecoveredwithquiltsandotheritemsthatcanbekeptwarmordirectlysaccharifiedinacontinuousgreenhouse.Thesecondistodeveloptothepoolwatertemperature.Undernormalconditions,itisnecessarytogotothecellartemperature,high-resolutionfermentationrateandflametemperature,controlthewatertemperatureandthepittemperature,soastoadapttothegrowthandmetabolismofmicroorganisms.Therefore,inwinter,whenthetemperatureislow,thedryingoffermentedgrainsandthemixingofkojiseedsareslightlydelayed,andthetemperatureoffermentedgrainsdropsrapidly.Whenthetemperatureislowerthan13℃,thesaccharificationofmouldandthefermentationofyeastareinhibited.Afterfermentation,thesurfaceofthegrainiscoveredwithwhitesweetandsourmycelium,andthetemperatureofafewdropsofsugarliquidatthebottomrisestotheheightofdrunkennessandbeginstodecline.Attheendofsaccharification,thetemperatureenterstheintoxicationpool.Finally,heatingandheatpreservation.Inordertoensurethenormalprocessofsaccharificationandliquefaction,itisnecessarytoensurethetemperaturerequiredforthewholefermentationprocess.
常用的方法是蓋上棉被等保溫，穿上一層草編的衣服，放入發酵罐，并建立恒溫發酵室。小型釀酒設施的發酵溫度尤為重要，因為溫度直接影響釀酒酵母的活性，同樣的重量，同樣的顆粒質量，發酵溫度不受控制，葡萄酒的產量和質量都會下降。雖然釀造曲酒是一種溫度適應范圍很廣的酒，在炎熱的夏季可以發酵，在冬季可以表現出良好的發酵活性，但是保持一個適當?shù)臏囟确秶梢允骨飘a生更好的效果。發酵保溫的另一種方法是利用蒸酒過程中產生的熱水對發酵室進行加熱。這個想法是在建造發酵室之前在地上建一個發酵室大小的池塘。這樣，起泡酒里的熱水就可以在冬天從進水口排出。由于水的比熱容較大，即使在寒冷的冬季，發酵室內的溫度仍然可以控制在適當?shù)陌l(fā)酵溫度。當夏季溫度較高時，可將井水或自來水放入池中冷卻，使發酵室冬暖夏涼。此外，在選擇或建造發酵室時，選擇厚墻的房屋是有利的。Thecommonmethodistocoverthequiltwithheatpreservation,putonalayerofstrawwovenclothes,putthemintothefermentationtank,andestablishaconstanttemperaturefermentationroom.Thefermentationtemperatureofsmallscalebrewingfacilitiesisparticularlyimportant,becausethetemperaturedirectlyaffectstheactivityofSaccharomycescerevisiae,thesameweight,thesameparticlequality,thefermentationtemperatureisnotcontrolled,andtheyieldandqualityofwinewilldecline.AlthoughQuliquorisakindofwinewithawiderangeoftemperatureadaptation,whichcanbefermentedinhotsummerandshowgoodfermentationactivityinwinter,keepingapropertemperaturerangecanmakeQuliquorproducebettereffect.Anothermethodoffermentationheatpreservationistousethehotwaterproducedintheprocessofsteamingwinetoheatthefermentationroom.Theideaistobuildapondthesizeofafermentationchamberonthegroundbeforebuildingit.Inthisway,thehotwaterinthesparklingwinecanbedischargedfromthewaterinletinwinter.Duetothelargespecificheatcapacityofwater,eveninthecoldwinter,thetemperatureinthefermentationroomcanstillbecontrolledattheappropriatefermentationtemperature.Whenthetemperatureishighinsummer,wellwaterortapwatercanbeputintothepooltocool,sothatthefermentationroomiswarminwinterandcoolinsummer.Inaddition,whenchoosingorbuildingfermentationrooms,itisadvantageoustochoosethickwallhouses.
以上就是
不銹鋼內膽實木酒桶對冬季快速發酵的方法的詳細介紹，想要了解更多請點擊官網
http://www.2010yyh.cn/
Theaboveisadetailedintroductiontothemethodofrapidfermentationinwinterinsolidwoodbarrelwithstainlesssteelliner.Formoreinformation,pleaseclickhttp://www.2010yyh.cn/
自動售酒機 2024-07-25 
